Plasma LED Bomber Jacket

insta1 insta2 insta3 insta4 insta5

Press photos

This is the story of the LED jacket I helped make for Chance the Rapper. The team consisted of Laura, Katrina, Victoria, and myself. Whitney Middleton is Chance’s lead stylist; she commissioned Laura and Katrina, her regular … ahh this is boring.

Whitney asked Laura and Katrina, and they found a lot of purpose-made hardware sold by the folks over at Adafruit. Laura contacted her engineering friend Victoria who contacted me, and I assured them it could be easily done. I sent them a bill of materials and drove up on Tuesday morning with my soldering iron and DMM. After over 500 individual stitches and solder joints, we finished in about 72 hours.

group

All of us working at the same time

Here are the broad strokes:

Adafruit makes a FLORA board that includes an Atmega32u4 microcontroller and is compatible with the Arduino IDE right out of the box.

Adafruit also makes Neopixels which are small but powerful RGB LEDs that can be controlled by a simple communication protocol described in this datasheet and implemented in this library on Github. The real beauty is that the Neopixels are chainable along the 1-wire data bus, the microcontroller’s memory capacity being the only limiting factor. We bought 160 of them, and ended up using 122.

sketch1 sketch2

The layout of the jacket

Power requirements. Each Neopixel is bright, and draws around 65mA at full power, so a fully lit up jacket would be drawing almost 8 amps. I got an RC car lithium polymer battery from amazon that was rated for high current draw. It was also a 7.4 volt battery, meaning it was two stacked lithium polymer batteries in series.

vrbox

The voltage regulator box supplies 5 V up to 8 A

The wiring took some thought. We were using 30 gauge silicon insulated stranded wire. This was fine for the data bus but each Neopixel needed to be connected to 5V and ground. Rough math was that we could only power about 12 Neopixels with the 30 gauge wire. 18 or 20 gauge lamp cord would have been beefy enough for the whole jacket, but using that thick a wire to each and Neopixel would not have been workable. It was a very tight fitting jacket to begin with, and he is a very dynamic performer. Anyway, the solution was to solder the power bus in groups of ~12 Neopixels with the 30 gauge wire, then have a short run of lamp cord soldered to each small “grouping” of Neopixels. The power bus for each group was also arranged in a ring pattern, which gave us a failsafe in case one of the solder joints (or wires) broke.

stitch

The neopixels stitched onto the jacket and the data bus soldered

Why did we solder all the joints and not use stainless steel thread like the Adafruit people recommend? Well, first, there are 3 wire busses running to and from every Neopixel. It’s a rats nest of wires in there and there’s really no way to be sure that exposed wire wouldn’t short. Perhaps if every bus had its own layer and we minimized cross stitching, but soldering each joint seemed like it would take less time. Also, at 8 amps, short circuits were a safety concern. We didn’t want to risk any short circuits.

debug

Turning the thing on after all that soldering, there were only 2 bugs

Programming the thing. The github library takes care of the PIO for the data bus, and also includes a data structure for storing the state of the Neopixels. Once you have your state–RGB color data for each Neopixel along the chain–you refresh the LEDs and viola. There are a whole lot of lighting tricks I programmed. View the code on Victoria’s Github here.

chance

Smoke break

A Walk in the Woods

This post is about hiking and camping, and why they are so great. Those two things, hiking and camping, are the two essences of being I think. Many people extoll the virtues of one and not the other, and those people are imbalanced.

wetrocks

Don’t slip

Most productive people like hiking more than camping. Hiking takes you places. You can find new persectives on the trail. All the shit rattling in your brain can be reorganized in a singe hike, it’s remarkable. They also probably like the exercise too. Can’t argue with that.

rocksitting

Smoky Mountains

But the greatest thing about hiking isn’t what it can do for you. Goal oriented people like the aforementioned qualities, and Everest climbers are probably the purest example of that. But the really beautiful thing about hiking is that it’s pretty much the same as not hiking. Or, more specifically, the same as going out and doing stuff. My memories of hiking are normally about the locations and people, not really what was going on with me at the time.

shelter

Trail people

Camping, on the other hand, makes people feel like they’re homeless. That’s why you gotta hike while you are camping. Anyone who camps and doesn’t hike is practicing the equivelent of staying at home and not going out. If you hike, then you are basically living like you normally do. It’s okay to stay in a little bit. A campsite on a lake is a very good reason to stay in.

mapreading

Which way do we go?

But what about hiking and not camping? It’s okay, I guess, but it isn’t the same. I do a lot of day hikes and no camping lately, but it kinda feels too escapist. I get back home and I think, “What is this place?”

When I get home from several days in the woods, I think to myself, “This is my home.”